Yamaha EF2400iSHC Bedienungshandbuch

GeneratorLIT-19626-01-697CF-28199-16PRINTED ON RECYCLED PAPERPRINTED IN JAPAN2011.04-0.8×1 !(E)EF2400iSHCOWNER’S MANUALRead this manual carefully befo

– 5 –7CF-0019 Do not operate the engine with a dust cover orother objects covering it.9 When covering the generator, be sure to do so onlyafter the en

– 6 –741-1221212AE01181CONNECTION NOTES9 Avoid connecting the generator to commercialpower outlet.9 Avoid connecting the generator in parallel with an

– 7 –AE00101DESCRIPTION56234111 1237793-14787 612345AE00103CONTROL PANEL1 Engine switch2 DC protector3 Oil warning light4 AC pilot light5 Overload ind

– 8 –700-121763-25912AE00111OIL WARNING LIGHT (Red)When the oil level falls below the lower level, the oilwarning light (Red) comes on and then the en

– 9 –741-123707-033a1707-1062707-107AE00845PRE-OPERATION CHECK Pre-operation checks should be made each time thegenerator is used.The engine and muffl

– 10 –700-1281700-103c1700-006AE00222ENGINE OILMake sure the engine oil is at the upper level of the oilfiller hole. Add oil as necessary.9 Immediatel

– 11 –700-006a1705-0751AE00955OPERATION9 Never operate the engine in a closed area or itmay cause unconsciousness and death withina short time. Operat

– 12 –4. Pull slowly on the recoil starter until it is engaged,then pull it briskly.5. After the engine starts, warm up the engine untilthe engine doe

– 13 –1AE01180APPLICATION RANGEWhen using the generator, make sure the total load is within rated output of a generator.Otherwise, generator damage ma

– 14 –1AE01172CONNECTIONAlternating Current (AC)Be sure any electric devices are turned off beforeplugging them in.9 Be sure all electric devices incl

Read this manual carefully before operating this machine. This manualshould stay with this machine if it is sold. 7CF-9-16 hyoshi 11.4.13 16:04 Page

– 15 –1AE00788Overload indicator light (Red)The overload indicator light (Red) 1 comes on whenan overload of a connected electrical device is detect-e

– 16 –762-0461212v762-047Battery chargingDo not connect a VRLA (Valve Regulated LeadAcid) battery. To charge a VRLA battery, a special(constant-voltag

– 17 –9 Be sure to connect the red battery charger leadto the positive (+) battery terminal, and connectthe black lead to the negative (-) battery ter

– 18 –Operating range of DC power supply (exclusively for charging 12-V battery)This power source is designed to charge batteries up to40Ah that are h

– 19 –763-2621705-075a2AE01173STOPPING THE ENGINETIPTurn off any electric devices.1. Disconnect any electric devices.2. Turn the engine switch to “STO

– 20 –AE00401PERIODIC MAINTENANCESafety is an obligation of the owner. Periodic inspection, adjustment and lubrication willkeep your generator in the

– 21 –*1·····Initial replacement of the engine oil is after one month or 20 hours of operation.*2·····The air filter element needs to be cleaned more

– 22 –788-0141 12760-0313a760-001aAE01051SPARK PLUG INSPECTIONThe spark plug is an important engine component,which should be checked periodically.1.

– 23 –4465700-1301700-13223AE00431CARBURETOR ADJUSTMENTThe carburetor is a vital part of the engine. Adjustingshould be left to a Yamaha dealer with t

– 24 –741-123788-016211AE01028MUFFLER SCREEN AND SPARK ARRESTERThe engine and muffler will be very hot after theengine has been run.Avoid touching the

AE00012IDENTIFICATION NUMBER RECORDSRecord your Primary I.D., and serial num-bers in the spaces provided, to assist youin ordering spare parts from a

– 25 –711-08012711-081711-0791711-0754. Remove the spark arrester 1.711-0783. Use a flathead screw driver to pry the sparkarrester out from the muffle

2. Remove the screws 3, and then remove the air fil-ter cover 4.3. Remove the foam element 5.4. Wash the foam element in solvent and dry it.Never use

– 27 –707-1081AE00471FUEL TANK FILTERNever use the gasoline while smoking or in thevicinity of an open flame.1. Remove the fuel tank cap and filter 1.

– 28 –707-106705-075b700-006763-261a791-001dAE01176TROUBLESHOOTINGEngine won’t start1. Fuel systemsNo fuel supplied to combustion chamber.2 No fuel in

A ENGINE DOES NOT STARTB– 29 –POKO CloggedC Does not flicker D Flickers.AE00515Turn the engine switch to “ON”, then pullthe recoil starter and check i

– 30 –AE00601STORAGELong term storage of your generator will require somepreventive procedures to guard against deterioration.4. Turn the fuel cock le

– 31 –6. Remove the screws 1, and then remove the cover2.7. Drain the fuel remaining in the carburetor into anapproved container by loosening the drai

– 32 –AE00621ENGINEPerform the following steps to protect the cylinder, pis-ton ring, etc. from corrosion.1. Remove the spark plug, pour about one tab

– 33 –AE00789EXHAUST EMISSION CONTROL SYSTEMAND COMPONENTSItem Acronym9 CARB. ASSY., LH. & JT., ...CARB (Carburetor)CARBURETOR

UnitEF2400iSHCType Air cooled 4-stroke gasoline OHVCylinder Arrangement Inclined, 1 cylinderDisplacement cm3171Bore × Stroke mm (in) 66.0 × 50.0 (2.60

AE00032PLEASE READ AND UNDERSTANDTHIS MANUAL COMPLETELY BEFOREOPERATING THE MACHINE.TIP9 Yamaha continually seeks advance-ments in product design and

– 35 –– 35 –YWWWWWWWYYYYYGOYLRYB/WOOB/WRRLLLLGGOOOOOOOB/WOYYYYYLLOOOOLLG/YG/YG/YG/YG/YYB/WYB/WB/WRRBrBrBBWBOB/WRRBrBrRBrBWB/WG/YG/YB/WLL1324oityrwque0

– 36 –YAMAHA MOTOR CORPORATION, U.S.A. EF SERIES GENERATORS 3-YEAR LIMITED WARRANTYYamaha Motor Corporation, U.S.A. hereby war-rants that new Yamaha g

– 37 –DAMAGES INCLUDING LOSS OF USE. SOMESTATES DO NOT ALLOW THE EXCLUSION ORLIMITATION OF INCIDENTAL OR CONSEQUEN-TIAL DAMAGES, SO THE ABOVE EXCLUSIO

– 38 –WARRANTY QUESTIONS AND ANSWERSQ. Is the warranty transferable to second own-ers?A. Yes. The remainder of the existing warrantycan be transfere

– 39 –YAMAHA OUTDOOR POWER EQUIPMENTCALIFORNIA EVAPORATIVE EMISSION CONTROL WARRANTY STATEMENTYOUR WARRANTY RIGHTS AND OBLIGATIONSThe California Air R

– 40 –YAMAHA MOTOR CORPORATION, U.S.A.SMALL OFF ROAD ENGINESCALIFORNIA EMISSION CONTROL WARRANTYYOUR WARRANTY RIGHTS AND OBLIGATIONSThe California Air

– 41 –instructions required by subsection (d) must be warranted for the warranty period defined inSubsection (b)(2). If any such part fails during th

– 42 –5. Air Injection SystemAir pump or pulse valveValves affecting distribution of flowDistribution manifold6. Catalyst or Thermal Reactor SystemC

– 43 –This warranty does not cover damage resulting from accidents, acts of nature, or other events or occur-rences beyond the control of Yamaha. Yama

– 44 –YAMAHA EXTENDED SERVICE (Y.E.S.) Keep your Yamaha Generator protected even after your warranty expires with genuine Yamaha ExtendedService (Y.E.

AE00041CONTENTSLOCATION OF IMPORTANT LABELS ...1SAFETY INFORMATION ...3EXHAUST FUM

7CF-9-16-c 11.2.23 1:41 PM Page 45

Read this manual carefully before operating this machine. This manualshould stay with this machine if it is sold. 7CF-9-16 hyoshi 11.4.13 16:04 Page

GeneratorLIT-19626-01-697CF-28199-16PRINTED ON RECYCLED PAPERPRINTED IN JAPAN2011.04-0.8×1 !(E)EF2400iSHCOWNER’S MANUALRead this manual carefully befo

To begin your 3 year warranty coverage, please register online within 30 days of purchase:www.yamahawarrantyregistration.comIf you prefer, you can com

PLACESTAMPHEREYAMAHA MOTOR CORPORATION U.S.A.P.O. BOX 6555CYPRESS, CA 90630ATTN: WARRANTY DEPARTMENT

– 1 –AE00062LOCATION OF IMPORTANT LABELSPlease read the following labels carefully before oper-ating this generator.TIPMaintain or replace safety and

– 2 –764HOT EXHAUST7WL-28176-103Electrocution or property damage can occur : Do not connect this generator to any building's electricalsystem un

– 3 –741-112AE00071SAFETY INFORMATION9 This generator is not designed for on-board use.Do not use it while installed on the vehicle.9 Do not modify th

– 4 –741-113741-114741-115741-116741-117AE00843ENGINE AND MUFFLER MAY BE HOT9 Place the generator in a place where pedestriansor children are not like