Yamaha EF1000iS Bedienungshandbuch

GeneratorLIT-19626-01-19 7CG-28199-10PRINTED ON RECYCLED PAPERPRINTED IN JAPAN049 04 – 1.2 × 1 !EF1000iSOWNER’S MANUAL 7CG-28199-10 hyoshi 3/22/04 4:

741-086a9 Keep the generator at least 1 m (3 ft) from build-ings or other equipment, or the engine may over-heat.a 1 m (3 ft)– 5 –741-087741-088741-08

1212741-090AE00088CONNECTION NOTES9 Avoid connecting the generator to commercialpower outlet.9 Avoid connecting the generator in parallel with anyothe

– 7 –793-104aqreyio!2w!1q793-105aute!0w!2AE00101CONTROL FUNCTIONqwer!1 !0 o i u793-106atyAE00103CONTROL PANEL1 Overload indicator light2 AC pilot ligh

AE00111OIL WARNING SYSTEMWhen the oil level falls below the lower level, theengine stops automatically. Unless you refill with oil,the engine will not

AE01099DC PROTECTORThe DC protector turns off automatically when the loadexceeds the generator rated output.cCReduce the load to the specified generat

741-091707-092707-095AE00845PRE-OPERATION CHECKNOTE:Pre-operation checks should be made each time thegenerator is used.wThe engine and muffler will be

700-116700-1191741-079AE01158ENGINE OILMake sure the engine oil is at the upper level of the oilfiller hole. Add oil as necessary.NOTE:Place the gene

– 12 –AE01109OPERATIONcC9 The generator has been shipped withoutengine oil. Fill with oil or it will not start.9 Do not tilt the generator when adding

– 13 –7. Push the choke knob back to the original position.4. Pull the choke knob fully out.1 Choke knobNOTE:The choke is not required to start a warm

NOTE:9 “–” means below.9 Application wattage indicates when each device isused by itself.9 The simultaneous usage of AC and DC power ispossible but to

7CG-28199-10 hyoshi 3/22/04 4:51 PM Page 2

763-222aq– 15 –761-079763-226q761-078aAE01023CONNECTIONAlternating Current (AC)cC9 Be sure all electric devices including the linesand plug connection

763-225qAE00953Overload indicator lightThe overload indicator light 1 comes on when anoverload of a connected electrical device is detected,the invert

AE01100Battery ChargingNOTE:The generator DC rated voltage is 12V.1. Wind the battery charging lead 2 or 3 turns aroundthe handle and plug into DC rec

762-012wNever smoke or make and break connections atthe battery while charging. Sparks may ignite thebattery gas.Battery electrolyte is poisonous and

– 19 –763-222q761-078763-223aq705-071dqONOFF707-097aAE01025STOPPING THE ENGINENOTE:9 Turn off any electric devices.9 Turn the economy control switch (

– 20 –AE00401PERIODIC MAINTENANCEAE00403MAINTENANCE CHARTRegular maintenance is most important for best performance and safe operation.wStop the engin

– 21 –* : It is recommended that these items be serviced by a Yamaha dealer.** : Related to emission control system.cCUse only Yamaha specified genuin

– 22 –760-024760-025q2. Check for discoloration and remove the carbon.3. Check the spark plug type and gap.a Gap4. Install the spark plug.5. Install t

7. Add engine oil to the upper level of the filler holeusing the oil filler guide.6 Oil filler guidecCDo not tilt the generator when adding engine oil

– 24 –NOTE:Recommended engine oil classification:API Service “SE” or “SF”.711-068q711-06932AE01028MUFFLER SCREEN AND SPARK ARRESTERwThe engine and muf

AE00012IDENTIFICATION NUMBER RECORDSRecord your Primary I.D., and serial num-bers in the spaces provided, to assist youin ordering spare parts from a

– 25 –711-050711-071a215. Remove the carbon deposits on the mufflerscreen and spark arrester using a wire brush.cCWhen cleaning, use the wire brush li

3. Remove the air filter cover and element 4.4. Wash the element in solvent and dry.5. Oil the element and squeeze out excess oil.The element should b

– 27 –707-094qAE00471FUEL TANK FILTER1. Remove the fuel tank cap and filter.1 Filter2. Clean the filter with solvent. If damaged, replace.3. Wipe the

– 28 –707-091AE01097TROUBLESHOOTINGEngine won’t start1. Fuel systemsNo fuel supplied to combustion chamber.2 No fuel in tank ... Supply fuel.2 Fuel i

– 29 –POKO CloggedEngine does notstart.C Does not flicker D Flickers.BAE00515A ENGINE DOES NOT STARTTurn the engine switch to “ON”, then pullthe recoi

– 30 –706-025788-001q707-103w712-026AE00601STORAGELong term storage of your machine will require somepreventive procedures to guard against deteriorat

– 31 –AE00789EXHAUST EMISSION CONTROL SYSTEMAND COMPONENTSItem Acronym9 CARB. ASSY., LH. & JT., ...CARB (Carburetor)CARBURETOR

– 32 –UnitEF1000iSType Forced air cooled 4-stroke gasoline OHVCylinder Arrangement Vertical 1 cylinderDisplacement cm350Bore × Stroke mm (in) 41.0 × 3

– 33 –770-044fWWWWWWWBrBrBrBrBrBrBrWWWBrBrBrBrBrWWWWWWWWWRRRBrRBrRWWLLLLLYBBB BBBBBBBRRRRLLL LGGYYORLGYOOB/WB/WB/WB/WB/WB/WB/WG/YG/YB/WB/WYYYYOOqrewt@

GeneratorLIT-19626-01-19 7CG-28199-10PRINTED ON RECYCLED PAPERPRINTED IN JAPAN049 04 – 1.2 × 1 !EF1000iSOWNER’S MANUAL 7CG-28199-10 hyoshi 3/22/04 4:

NOTE:9 Yamaha continually seeks advance-ments in product design and quality.Therefore, while this manual containsthe most current product informationa

AE00041CONTENTSSPARK PLUG INSPECTION ...22CARBURETOR ADJUSTMENT...22ENGINE OIL REPLACEMENT ...23MUFFLER SCREEN AND SPARKARRESTE

– 1 –AE01120YAMAHA MOTOR CORPORATION U.S.A. EF- AND EDL-SERIES GENERATOR LIMITED WARRANTYYamaha Motor Corporation, U.S.A. hereby war-rants that new Ya

– 2 –WARRANTY QUESTIONS AND ANSWERSQ. Is the warranty transferable to second own-ers?A. Yes. The remainder of the existing warrantycan be transfered u

– 3 –q792-050erw792-051dytHOT EXHAUST7VV-28176-10AE00062LOCATION OF IMPORTANT LABELSPlease read the following labels carefully before oper-ating this

741-080AE00071SAFETY INFORMATIONAE00072EXHAUST FUMES ARE POISONOUS9 Never operate the engine in a closed area or itmay cause unconsciousness and death